SDS

A listing of SDS's
SAFETY DATA SHEET
Carbol Fuchsin, strong stain
1. IDENTIFICATION
Product Identifiers
Product Name:
Carbol Fuchsin, strong stain
Other Names:
2821 PHENOL SOLUTION
CARBOL FUCHSIN 1% STAIN
Product Number(s):
ACF-500
CAS Number:
-
Recommended use of the chemical and restriction on use
Laboratory use.
Company Details
ProSciTech Pty Ltd
11 Carlton Street
KIRWAN QLD 4817
Australia

(07) 4773 9444
www.proscitech.com
Emergency Contact Details
ProSciTech Pty Ltd
11 Carlton Street
KIRWAN QLD 4817
Australia

(07) 4773 9444
www.proscitech.com
2. HAZARDS IDENTIFICATION
Classification of the substance or mixture
Hazardous Nature: Classified as Hazardous according to the Globally Harmonised System of Classification and Labelling of Chemicals (GHS) and Safe Work Australia criteria. Classified as Dangerous Goods according to the Australian Code for the Transport of Dangerous Goods by Road and Rail (7th edition)
Label Elements
Signal Words
Danger
Hazard Statement(s)
H302+H312+H332 Harmful if swallowed, in contact with skin or if inhaled.
H314 Causes severe skin burns and eye damage.
H341 Suspected of causing genetic defects.
Precautionary Statement(s)
P260 Do not breathe dust/fume/gas/mist/vapours/spray.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
P264 Wash hands thoroughly after handling.
P270 Do not eat, drink or smoke when using this product.
P271 Use only outdoors or in a well-ventilated area.
P201 Obtain special instructions before use.
P202 Do not handle until all safety precautions have been read and understood.
P303+P361+P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower.
.P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.
P310 Immediately call a POISON CENTER/doctor.
P321 Specific treatment (see on this label).
P301+P312 IF SWALLOWED: Call a POISON CENTER/doctor if you feel unwell.
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.
P363 Wash contaminated clothing before reuse.
P308+P313 IF exposed or concerned: Get medical advice/attention.
P301+P330+P331 IF SWALLOWED: rinse mouth. Do NOT induce vomiting.
P362+P364 Take off contaminated clothing and wash it before reuse.
P405 Store locked up.
P501 Dispose of contents/container in accordance with local/regional/national regulations.
Primary route(s) of entry
Not available.
Human Health
Inhalation:
Not available.
Ingestion:
Not available.
Eyes:
Not available.
Skin:
Not available.
Environment
No further relevant information available.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Name
CAS No.
Content (w/w)
Classification
phenol
108-95-2
~5%
Acute Tox. 3, H301; Acute Tox. 3, H311; Acute Tox. 3, H331; Muta. 2, H341; STOT RE 2, H373; Skin Corr. 1B, H314
Ethanol
64-17-5
~5%
Flam. Liq. 2, H225
4. FIRST AID MEASURES
Ingestion
If swallowed, do not induce vomiting. Immediately rinse mouth with water. Give 3-4 glasses of water to drink. Never give anything by mouth to an unconscious person. Seek immediate medical attention.
Inhalation
If inhaled, remove to fresh air. If not breathing, give artificial respiration. Do not use mouth-to-mouth method if victim inhaled the substance. Induce artificial respiration with the aid of a pocket mask equipped with a one way valve or other proper respiratory medical device. If breathing is difficult, give oxygen. Seek medical attention if breathing problems develop.
Skin Contact
In case of skin contact, immediately remove contaminated clothing and wash affected areas with water and soap and then rinse with methylated spirits. Seek immediate medical attention.
Eye Contact
In case of eye contact, hold eyelids open and rinse with water for at least 15 minutes. Seek immediate medical attention.
Other Information
This substance is capable of causing serious irreversible effects after a single exposure. Such irreversible effects can include central nervous system effects, kidney necrosis, liver lesions, anemia or paralysis. Inhalation: Harmful if inhaled. May cause respiratory irritation, coughing, discomfort, difficulty breathing and shortness of breath.
Skin Contact: Harmful in contact with skin. Causes severe skin burns. May cause irritation, redness, itchiness and skin dryness. May be toxic if absorbed through the skin.
Eye Contact: Causes serious eye damage, irritation, tearing, stinging, blurred vision and pain. Ingestion: Harmful if swallowed. May cause irritation of mouth, throat and stomach, mucous build up, stomach pain, nausea, vomiting and diarrhoea.
5. FIREFIGHTING MEASURES
Suitable extinguishing equipment
Water fog, foam, dry chemical or carbon dioxide.
HAZCHEM
Not available.
Special protective equipment and precautions for fire fighters
Hazardous combustion products include acrid smoke and fumes. This material does not burn. Use water spray to cool fire exposed containers. When fighting a major fire wear self-contained breathing apparatus and protective equipment.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures
Wear approved respiratory protection, chemical resistant gloves, protective clothing and safety boots. Evacuate all non-essential personnel from affected area. Do not breathe vapours. Ensure adequate ventilation. Extinguish all sources of ignition. Avoid sparks and open flames. No smoking. Do not walk or touch spilt material.
Environmental precautions
In the event of a major spill, prevent spillage from entering drains or water courses.
Methods and materials for containment and clean up
Stop leak if safe to do so and absorb spill with sand, earth, vermiculite or some other absorbent material. Do not use sawdust. Collect the spilled material and place into a suitable container for disposal. Use only nonsparking tools.
For large spills, contact emergency services, bund the area and blanket the spill with foam or use water fog to disperse vapours.
7. HANDLING AND STORAGE
Precautions for safe handling
Use of safe work practices are recommended to avoid eye or skin contact and inhalation of vapours. Use only outdoors or in a well-ventilated area.
Food, beverages and tobacco products should not be stored or consumed where this material is in use. Always wash hands before smoking, eating, drinking or using the toilet. Wash contaminated clothing and other protective equipment before storage or re-use. Provide eyewash fountains and safety showers in close proximity to points of potential exposure.
Conditions for safe storage
Store in a cool, dry and well ventilated area. Keep in original container, tightly closed when not in use. Protect from direct sunlight, heat, sparks, open flames and other sources of ignition. Keep away from strong oxidising agents, strong alkalies, combustible materials, nitrates and acids.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Standards
Material
TWA ppm
TWA mg/m3
STEL ppm
STEL mg/m3
2 phenol
1 ppm
4 mg/m³,
-
-
5 Ethanol
1000 ppm
1880 mg/m³
-
-
Engineering controls
Provide exhaust ventilation or other engineering controls to keep the airborne concentrations of vapour below occupational exposure standards.
Personal protective equipment
Eye and face protection
Eye and face protectors for protection against splashing materials or liquids. See Australian/New Zealand Standard AS/NZS 1337 for more information.
Skin protection
Nitrile or neoprene gloves. See Australian/New Zealand Standard AS/NZS 2161 for more information. When selecting gloves for use against certain chemicals, the degradation resistance, permeation rate and permeation breakthrough time should be considered.
Occupational protective clothing (depending on conditions in which it has to be used, in particular as regards the period for which it is worn, which shall be determined on the basis of the seriousness of the risk, the frequency of exposure to the risk, the characteristics of the workstation of each worker and the performance of the protective clothing). See Australian/New Zealand Standard AS/NZS 4501 for more information.
Body protection
No information available.
Respiratory protection
When vapours approach the exposure standards then the use of a half-face organic vapour respirator with dust/mist filter is recommended.
When vapours exceed the exposure standards, the use of an positive pressure demand self-contained or airline breathing apparatus is recommended. Filter capacity and respirator type depends on exposure levels. If entering spaces where the airborne concentration of a contaminant is unknown then the use of a self contained breathing apparatus (SCBA) with positive pressure air supply is recommended. See Australian Standards AS/NZS 1715 and 1716 for more information.
9. PHYSICAL AND CHEMICAL PROPERTIES
General information
Appearance
Dark red liquid
Odour
Not available.
pH
Not available.
Vapour Pressure
20 °C: 30 hPa
Density
1.02
Boiling Point
90 °C (approx.)
Melting Point
-5 °C
Solubility
Completely soluble in water.
Specific Gravity of Density
Not available.
Flash Point
Not applicable.
Flammable (Explosive) Limits
Not applicable.
Ignition Temperature
Not available.
Formula
Not available.
10. STABILITY AND REACTIVITY
Reactivity
No further relevant information available.
Chemical stability
Stable at ambient temperature and under normal conditions of use.
Possibility of hazardous reactions
Hazardous polymerisation will not occur.
Conditions to avoid
Heat, sparks, open flames and other sources of ignition.
Incompatible materials
Strong oxidising agents, strong alkalies, combustible materials, nitrates and acids.
Hazardous Decomposition Products: Acrid smoke and fumes.
11. TOXICOLOGICAL INFORMATION
Acute effects
Repeated or prolonged exposure may cause de-fatting of the skin and dermatitis, severe eye irritation and possible blindness. May cause tumours in the liver and thyroid.
This substance is capable of causing serious irreversible effects after a single exposure. Such irreversible effects can include central nervous system effects, kidney necrosis, liver lesions, anemia or paralysis.
Eye contact
Causes serious eye damage, irritation, tearing, stinging, blurred vision and pain. This substance is capable of causing serious irreversible effects after a single exposure.
Skin contact
Harmful in contact with skin. Causes severe skin burns. May cause irritation, redness, itchiness and skin dryness. May be toxic if absorbed through the skin. This substance is capable of causing serious irreversible effects after a single exposure.
Ingestion
Harmful if swallowed. May cause irritation of mouth, throat and stomach, mucous build up, stomach pain, nausea, vomiting and diarrhoea. This substance is capable of causing serious irreversible effects after a single exposure.
Inhalation
Harmful if inhaled. May cause respiratory irritation, coughing, discomfort, difficulty breathing and shortness of breath. This substance is capable of causing serious irreversible effects after a single exposure.
Toxicity and irritation
108-95-2 phenol
Oral LD?? 317 mg/kg (rat)
Dermal LD?? 850 mg/kg (rabbit)
64-17-5 Ethanol
Oral LD?? 7060 mg/kg (rat) Inhalation
LC??/4 h 20000 mg/l (rat)
12. ECOLOGICAL INFORMATION
Ecotoxicity
No further relevant information available.
Persistence and degradability
No further relevant information available.
Bioaccumulative potential
No further relevant information available.
Other adverse effects
No further relevant information available.
13. DISPOSAL CONSIDERATIONS
General information
Dispose according to applicable local and state government regulations.
Special Precautions for Landfill or Incineration:
Please consult your state Land Waste Management Authority for more information.
14. TRANSPORT INFORMATION
ADG label required
HAZCHEM
Not available.

UN Number
UN2821
Proper shipping name
2821 PHENOL SOLUTION
Transport hazard class
6.1
Packing group
PG III
Environmental hazard
No
Special precautions for users
Special Provisions: 223
Limited Quantities: 5L
Additional information
Packagings & IBCs - Packing Instruction: P001, IBC03, LP01 Packagings & IBCs - Special Packing Provisions: No information available.
Portable Tanks & Bulk Containers - Instructions: T4
Portable Tanks & Bulk Containers - Special Provisions: TP1
15. REGULATORY INFORMATION
Poisons Schedule Number
Poisons Schedule: 6
Other Information
No further relevant information available.
16. OTHER INFORMATION
SDS preparation date
7 August 2017
Comments
This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship.
This Safety Data Sheet (SDS) has been prepared in compliance with the Preparation of Safety Data Sheets for Hazardous Chemicals Code of Practice February 2016. It is the user's responsibility to determine the suitability of this information for adoption of necessary safety precautions. The information published in this SDS has been compiled from the publications listed in Section 16: to the best of our ability and knowledge these publications are considered accurate. We reserve the right to revise Safety Data Sheets as new information becomes available. Copies may be made for non-profit use.

... End of SDS ...